MMD > Archives > December 2014 > 2014.12.22 > 01Prev  Next


Making Piano Roll Pull Tabs & D-rings
By John Phillips

Hello MMD.  Living in far-flung corner of the (former) British
Empire, I find that piano roll repair supplies are not always readily
available.  Pull tabs fall into the "not available" category so I make
my own.  I use bookbinding cloth, scraps of which can be obtained from
local bookbinders, who often are glad to get rid of them.

I removed a tab in good shape from a discarded roll and opened it out.
When the tab was well flattened I traced around it on to a sheet of
paper.  I cut out the outline and glued it to a scrap of sheet metal
about 1 mm thick.  I used various sheet metal tools to cut away all the
metal outside the tab outline, leaving me with a pattern for future
tabs.

To make a new tab I lay a scrap of bookbinding cloth on a cork tile,
hold the pattern firmly on top and cut around it with a scalpel.
I make D-rings by using a metal rod of circular cross-section that has
had half of its material machined away for about 1 cm from one end.

Held in a vice this provides a D-shaped pattern around which I can bend
a length of steel wire.  Cutting off the surplus ends of the wire makes
a respectable looking D-ring.  An opened out plated steel paper clip
provides enough material for one D-ring.

I used to glue the tab on with P.P.Co's PVC-E glue, but that is no
longer available, so these days I use an Australian product called
Evo-Stick, which I suspect is the same stuff.

John Phillips - in Hobart, Tasmania



(Message sent Mon, 22 Dec 2014 20:56:57 +1100 , from time zone +1100.)

Key Words in Subject:  D-rings, Making, Piano, Pull, Roll, Tabs

Related by Subject:
2014.12.22.01 (This article) - Making Piano Roll Pull Tabs & D-rings
2025.07.05.03 - Audio-To-MIDI Transcriptions For Making Piano Rolls
from Piotr Barcz
2024.01.25.02 - Making Wurlitzer Unit Valves
from Wallace Venable
2024.01.24.03 - Making Wurlitzer Unit Valves
from Jeff Kunkel
2022.03.19.01 - Paper Tape Marking Pen and Transport Kit
from Mark Kinsler
2021.03.25.01 - Video: The Making of the Seabreeze Carousel
from Matthew Caulfield
2021.03.25.05 - FS: Tools for Making Barrels for Barrel Organs
from Anatoly Zayaruzny
2021.03.24.01 - Video: The Making of the Seabreeze Carousel
from Andrew Lardieri
2020.12.26.03 - Making Wurlitzer Unit Valves
from Don Teach
2020.08.13.03 - Making Chime Rods
from Karl Schröder
2020.08.11.03 - Making Chime Rods For Chiming Clocks
from Mark Kinsler
2019.10.28.02 - Making Wurlitzer Band Organs Play Caliola Rolls
from Glenn Thomas